Ex-500.com - The home of the Kawasaki EX500 / Ninja 500R banner
Cancel

Search Results for ‘coolant’

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-4 of 4 Results

Search Tags

06ninja500 2002ninja500r 2006ninja 250 abs air box bar ends beginner carb carb issues carbs carburetor chain adjustment choke clutch clutch plates complete rebuild connecting rod coolant coolant fan problem custom custom exhaust cylinder ducatiman electrical engine engine noise engine problems engine rebuilding er5 ex500 ex500r exhaust fairing flipflop flywheel fog fuel issue fuse gas leak gas tank gear gen1 gen2 handlebar help idle introduction kawasaki kle 500 leak maintenance modification neutral new new rider newbie newninjaowner ninja no power no start nofuel noise not starting notstarting oil plug power problem problems projectbike rebuild repair screw seat solenoid spark spark plug stalling starter starter gear starter motor starting issues stator sticky throttle stock street fighter streetfighter stuck clutch suspension throttle tube tires transmission tripletree troubleshooting turn signal mod upgrades wiring wont start wontstart
  1. Troubleshooting
    Greetings, First, I did a search of the forum and found LOTS of posts about coolant IN OIL, but only a few about oil IN COOLANT. If this issue I have described has been addressed, please accept my apologies, and I humbly accept a flaming and possibly a link to my answer. I have a 2000 EX-500...
    coolant film leak oil skim
  2. Engine
    So I have coolant leaking at the pump. I am pretty sure that where it is leaking is at the mechanical seal that presses against the impeller. My question is: if I am replacing the mechanical seal, should I replace the oil seal with the spring on it too or is it probably good? Here is a picture...
    coolant leak seal water pump
  3. General Discussion
    I just did a coolant flush on my ‘99 ex500. It had some super green coolant in it but it looked old so I replaced it with supertech extended life. Said it’s safe for aluminum and free of all the crap that we’re supposed to stay away from. I flushed it only once and the stuff that came out when I...
    coolant
  4. Troubleshooting
    Hi all, I've been riding a Ninja 500 for 2 years and stored in cold canadian winters. One day, I very briefly saw some white smoke rising from the engine upon startup, then nothing. Took it out for a ride, no temperature problems at all. Took the belly fairing off, and there is dried white...
    coolant leak
1-4 of 4 Results
Top